新聞中心
新聞資訊
聯系我們
山東途暢路橋工程有限公司
聯系人：石總
電話：18264104888
地址：山東省濟南市槐蔭區經一路273號群盛華城
粉料撒布車比人工撒布好在哪里？
來源：http://www.baitaiglass.com/ 日期：2019-11-20 發布人：
如今人工成本的愈發高漲，還有國家對于環境保護的重視，用粉料撒布車替代人工撒布就已經成為了一個必然的趨勢，那么使用撒布車比人工好在哪里呢？施工成本能夠降低多少呢？下面小編就來講解一下。
Nowadays, the labor cost is increasing, and the state attaches great importance to environmental protection. It has become an inevitable trend to replace manual spreading with powder spreader. What is the better use of spreader than manual operation? How much can the construction cost be reduced? Let's talk about it.
粉料撒布車比人工撒布好在哪里？
What are the advantages of powder spreader than manual spreader?
以開展20cm厚混凝土就地冷再生為例，混凝土使用量5%，約再造5000平方米，每日要用混凝土量115噸，花費比較如下：
Taking 20 cm thick concrete in situ cold recycling as an example, the concrete consumption is 5%, about 5000 square meters is recycled, and the daily concrete consumption is 115 tons. The cost comparison is as follows:
人工鋪攤：人工工資3000,25人，薪水120，柴油機費200，拖拉機400，混凝土花費36800等等，終總花銷40400。粉料撒布車：人工200，混凝土34500，柴油機費240，終總成本34940。
Manual paving: 3000, 25 people, 120 salary, 200 diesel engine fee, 400 tractor, 36800 concrete cost, etc., and the final total cost is 40400. Powder spreader: Labor 200, concrete 34500, diesel engine cost 240, final total cost 34940.
本推算假設了混凝土使用量相同，效率一樣等前提，實際上在真實的運用過程中粉料撒布車還會存有以下兩方面的優點：
This calculation assumes that the concrete consumption is the same and the efficiency is the same. In fact, in the actual application process, the powder spreader will have the following two advantages:
1、機器設備灑布與再生機同步，進而減小了混凝土的損失，通常較人工灑布能夠降低0.5%的混凝土消耗量，即用人工灑布時混凝土實際上控制使用量要較理論摻入量提升1%，而用機器設備灑布控制提升0.5%即可；
1. In general, the concrete consumption can be reduced by 0.5% compared with manual spraying, that is to say, when using manual spraying, the actual control consumption of concrete should be increased by 1% compared with the theoretical mixing amount, while the control amount with machine equipment can be increased by 0.5%;
2、機器設備灑布要較人工效率高，每一小時的灑布總面積就達到4000平方米，經可供應5臺冷再生同時作業。因效率的提高，單位總面積內所包含的機械設備費與人工費都會大幅度減少，為顧客節約成本。
2. The spraying efficiency of machinery and equipment is higher than that of labor. The total area of spraying per hour is 4000 square meters, which can supply 5 sets of cold regeneration at the same time. Due to the improvement of efficiency, the cost of mechanical equipment and labor in the unit area will be greatly reduced to save costs for customers.
以上就是關于粉料撒布車對比人工撒布所具有的優勢分析了，相信大家大多能夠看出撒布車的優勢所在了。
The above is the analysis of the advantages of powder spreader compared with manual spreader. I believe everyone can see the advantages of spreader.
上一條：路面冷再生機的組成和工作原理！
下一篇：冷再生機可以在哪些方面進行施工？ 上一篇：冷再生機在公路養護中作用
推薦閱讀/ Recommended reading
- 水泥撒布車出租是路面基層施工的“合理鋪灰神器” 2026-07-05
- 租賃冷再生機哪幾點要注意？ 2026-07-07
- 冷再生機租賃從設備選型到驗收避坑，一篇講透 2026-07-09
- 水泥撒布車租賃市場洞察與科學選型指南 2026-06-29
冷再生機租賃時核心關注這四大核心指標
[2026-07-11]
第一，撒布精度——這是水泥撒布車的“生命線”。 租賃粉料撒布車時，核心要看控制系統是否具備自動恒速撒布功能——即車輛行駛速度變化時，撒布量依然保持恒定。現代智能化撒布車以進口車載...
